Product ID:F-09P03, 3C F-152 TY I MODIFIED 23655 (SUPDAT)
MSDS Date:02/01/1994
FSC:8010
NIIN:00N069794
Kit Part:Y
MSDS Number: CBKVS

SEAGRAVE COATINGS CO

3560 ELM AVE
PORTSMOUTH, VA 23704
US

Emergency Phone: 804-397-2223

Info Phone: 804-397-2223

Cage: 60163

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

0.0 @ 20C

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 5%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

0.0 @

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 5%

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 0.1 MG/M3 RDUST

BUTYL ALCOHOL; (N-BUTYL ALCOHOL) (SARA 313) (CERCLA).

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: 30%

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

3.41. VOLATILE ORGANIC

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:BREATHING OF HIGH VAPOR
CONCENTRATIONS MAY PRODUCE NARCOSIS. LIQUID MAY CAUSE MINOR SKIN
IRRITATION & DEFINITE EYE IRRITATION. CAUSES NOSE AND THROAT
IRRITATION. CAUSE EYE IRRITATION. CAUSES SKI N IRRITATION. MAY BE
HARMFUL IF ABSORBED THRU SKIN. CHRONIC:REPEATED & PROLONGED OVEREXP
TO SOLVENTS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC MONO,
SUPP, VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL RPT ON CARCINS,
1994: (SUPDAT)
Effects of Overexposure:HLTH HAZ:COULD CAUSE PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:REMOVE TO FRESH AIR, RESTORE BRTHG. CONSULT PHYS.
SKIN:FLUSH W/WATER FOR @ LEAST MINS WHILE REMOVING CONTMD
CLTHG/SHOES. GET IMMED MED ATTN. WASH CLTHG BEFORE REUSE. DESTROY
SHOES. EYE:FLUSH IMM ED W/LG AMTS OF WATER FOR @ LEAST 15 MINS.
CONSULT PHYS. INGEST:GET MEDICAL ATTENTION IMMEDIATELY.

Flash Point Method:SCC
Flash Point:99.0F,37.2C
Lower Limits:1.4%
Upper Limits:11.2%
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CONTAINERS. IF WATER IS USED
FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. VAPS MAY
MIGRATE TO IGNIT SOURCES & CAUSE FLASH FIRE. ISOLATE FROM HEAT,
SPKS, ELEC EQUIP, APPLIANCES, PILOT LIGHTS, FLAMES & (SUPDAT)

Spill Release Procedures:IN CASE OF SPILLAGE ABSORB WITH INERT MATERIAL
AND DISPOSE OF IN ACCORDANCE WITH APPLICABLE REGULATIONS OF EPA AND
OTHER LOCAL, STATE AND FEDERAL AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AWAY FROM HEAT, SPARKS & OPEN
FLAME. AVOID PRLNGD SKIN CONT. DO NOT BREATHE SPRAY MIST.
Other Precautions:STORE IN COOL DRY AREA W/VENT SUITABLE FOR STORING
MATLS SHOWN IN INGRED SECTION. GROUND CNTNRS WHILE POURING. AVOID
SPONT COMBUST OF CONTAMD RAGS/OTHER ORG MATLS. EMPTY CNTNRS MAY
RETAIN HAZARDOUS PR OPERTIES & CAN BE DANGEROUS.

Respiratory Protection:NIOSH/MSHA APPRVD RESP TYPES SUITABLE FOR MATLS
IN INGRED SECTION REC. NIOSH/MSHA APPRVD CHEM/MECH FILTERS REC WHEN
VENT IS RESTRICTED. DO NOT BREATH (DUST, VAPS/SPRAY MIST). WEAR
APPROP, RESP (NIOSH/ MSHA APPRVD) DURING & AFTER (SUPDAT)
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE PROVIDED TO
KEEP AIR CONTAM BELOW CURRENT APPLIC OSHA PEL EXPOS (SUPDAT)
Protective Gloves:CHEMICAL RESISTANT PLASTIC/RUBB GLOVES.
Eye Protection:ANSI APPRVD CHEM WORK GOGG & (SUPDAT)
Other Protective Equipment:AS REQD TO AVOID WETTING CLTHG. PROTECTIVE
CREAMS. ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:AVOID CONTACT WITH EYES, SKIN, AND CLOTHING.
WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:ORGANIC COATING. EXPLO HAZ:OTHER SOURCES OF
IGNIT. FLAMM LIQ & VAP. EXPLAN OF CARCIN:ANTIC TO BE CARCIN. RESP
PROT:APPLIC UNLESS AIR MONITORING RECORDS VAP/MIST LEV BELOW APPLIC
LIM. FOLLOW RESP MFR DIRECTIONS FOR USE. VENT:LIM/ACGIH'S TLV LIM.
USE W/ADEQ VENT. EYE PROT:FULL LENGTH FSHLD .

Boiling Pt:B.P. Text:>243F,>117C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID, ALCOHOL ODOR.
Percent Volatiles by Volume:50.6

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OR OPEN FLAME.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
IN ACCORDANCE WITH LOCAL, COUNTY, STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.